DRYING KINETICS OF FISH (Clarias gariepinus) SMOKED WITH BIOGAS

Authors

  • O. S. Oyerinde
  • John A. V. Olumurewa a:1:{s:5:"en_US";s:21:"FST Dept., FUT. Akure";}
  • D. Fajobi Department of Food Science and Technology, The Federal University of Technology, Akure

DOI:

https://doi.org/10.51459/futajeet.2021.15.2.254

Keywords:

equilibrium moisture content, Fish, smoking, biogas

Abstract

This is aimed at studying the aeration kinetics of catfish (Clarias gariepinus) smoked directly with biogas. Five live fresh fishes (Clarias gariepinus) were obtained from Fishery and Aquaculture Technology Department in FUTA, Ondo State, Nigeria at the age of 4 months with average weight of 900g each. The fishes were killed, de-gutted, thoroughly washed with water, cut into pieces of 3cm length. The chunks were laid in a single layer on a mesh directly exposed to biogas flame obtained from bio-decomposition of poultry waste and the weight was being monitored at 15 minutes interval until constant weight was observed. The study showed that the time taken for drying of Clarias gariepinus to reach the humidity point of around 12.43% (db.) was two and a half hours. The drying data was subjected to 10 thin-layer drying models. The compared the performances of the models using the determination of coefficient (R2), reduced chi­square (x2) and root mean square error (RMSE) between the calculated and predicted moisture ratios. The results showed that Henderson and Pabis modified model (highest R2 and lowest x2 and RMSE of 0.998, 0.00021 and 0.01386 respectively) was found to satisfactorily describe the biogas drying curves of Clarias gariepinus.

References

Abba K. A., Saleh A. M., Mohammed A. and Lasekan 0., (2009). "The Relationship between water activity and fish spoilage, A Review".Journal of Food, Agricultural and Environment 7:86-90.

Abidemi-Iromini 0. A., Olawusi-Peters 0. 0., Fadeyi A., and Bello-Olusoji 0. A., (2011). Smoking impact on the microbial load of Clarias gariepinus ". Ethiopian Journal of Environmental Studies and Management4 (3):38-41

Ayensu A., (1997). "Dehydration of food crops using a solar dryer with convective heat flow". Solar Energy, 59:121-126.

Babalis J. S. and Belessiotis G. V., (2006). "Influence of drying condition on the drying constants and moisture diffusivity during the thin layer drying of figs". Journal of Food Engineering, 65: 449-458

Bellagha, S., Amami, E., Farhat A. and Kechaou N., (2002). "Drying kinetics and characteristic drying curve of lightly salted sardine (Sardinella aurita)", Drying Technology, 20 (7), pp. 1527-1538

Bellagha, S., Sahli, A., Farhat, A., Kechaou, N. and Glenza, A., (2006). "Studies on the salting and drying of sardine (Sardinella aurita): Experimental kinetics and modeling", Journal of Food Engineering, 78:pp. 947-952

Boeri, C., de Silva, F.N., Ferriera, J., Saraiva, J. and Salvador, A., (2011). "Predicting the drying kinetics of salted codfish (Gadus morhua ): semi-empirical, diffusive and neural network models". International Journal of Food Science and technology, 46, pp. 509-515

Celma,A. R, S. Rojas, F. Lo'pez, I. Montero and T. Miranda, (2007). "Thin-layer drying behavior of sludge of olive oil extraction". Journal of Food Engineering, 80: 1261-1271

Chavan, B. R., Yakupitiyage, A. and Kumar, S. (2008). "Mathematical modeling of drying characteristics on Indian mackerel ( Rastrilliger kangurta) in solar-biomass hybrid cabinet dryer". Journal of Drying Technology, 26:1552-1562

Davies, R. M., Davies, 0. A., Inko-Tariah, M. B. and Bekibele, D. 0. (2008). "Mechanization of fish farms in Rivers State, Nigeria". World Appied. Science Journal,3(6): 926-929

Doymaz, I., (2005b). Sun drying of figs: an experimental study. Journal of Food Engineering 71:403-407.

Doymaz, I., (2007). The kinetics of forced convective air-drying of pumpkin slices. Journal of Food Engineering, 79: 243-248.

Duncan, D. B. (1955). Multiple range and multiple F test. Biometrics .,11:1-42.

Eyo A. A., (2001). "Fish processing Technology in the Tropics". Published by National Institute for Freshwater Fisheries Research (NIFFR), P.M.B. 6006, New Bussa, Niger State.

FAO, (2014). Food and Agriculture Organization of the United Nations." Sustainable fisheries and aquaculture for food security and nutrition", pp.119. https://www.fao.org/documents/card/en/c/63d4de950d49bl-b6d2-b7d0368744ea Accessed 15 July, 2015

Gupta S. K. and Gupta, P. C. (2006). "General and applied ichthyology (fish and fisheries)", S.Chandandco.Ltd

Hii, C. L., Law, C. L., and Cloke, M., (2009). "Modeling using a new thin layer drying model and product quality of cocoa". Journal of Food Engineering, 90: 191 - 198.

Jain, D. and Pathare, P. B. (2007). "Study the drying kinetics of open sun drying of fish", Journal of Food Engineering, Vol. 78, pp. 1315-1319

Joshi C. B., Gewali, M.B. and Bhandari, R. C. (2005). "Performance of solar drying systems: a case of Nepal". Institution of Engineers (India) Journal, 85 (2): 53-57.

Kaleemullah S. and Kailappan R., (2006). "Modeling of thin layer drying kinetics of red chillies". Journal of Food Engineering, 76(4): 531-537.

Karathanos, V. T., (1999). "Determination of water content of dried fruits by drying kinetics". Journal of Food Engineering, 39: 337-344.

Kashaninejad, M., and Tabil, L. G., (2004). "Drying characteristics of purslane (Portulaca oleraceae L.)". Drying Technology, 22: 2183-2200.

Kaya, A., Aydin, 0., Demirtas, C. and Akgiin, M., (2007). "An experimental study on the drying kinetics of quince". Desalination 212: 328-343.

Kituu, G. M., Shitanda, D., Kanali, C. L., Mailutha, J. T., Njoroge, C. K., Wainaina, J. K. and Silayo, V. K., (2010). "Thin layer drying model for simulating the drying of Tilapia fish (Oreochromis niloticus) in a solar tunnel dryer", Journal of Food Engineering, 98: pp. 325-331

Lahsasni, S., Kouhila, M., Mahrouz, M. and J. T. Jaouhari, (2004b). "Drying kinetics of prickly pear fruit (Opuntia ficus indica)". Journal of Food Engineering,61: 173-179.

Lui Q., Bakker-Arkema F. W., (1997). "Stochastic modeling of grain drying. Part 2: Model development". Journal of Agricultural Engineering Research, 66:275-80.

Midilli, A. and Kucuk, H., (2003). Mathematical modeling of thin layer drying of pistachio by using solar energy. Energy Conversion and Management, 44(7):1111-1122.

Midilli, A., Kucuk, H. and Yapar, Z., (2002). A new model for single-layer drying. Drying Technology, 20: 1503-1513.

Mujaffar, S. and Sankat, C. K., (2006). "The mathematical modeling of the osmotic dehydration of shark fillets at different brine temperatures". International Journal of Food Science and Technology, 41 (4),pp.405-416

Odote, P. M. 0., Kituu, G. M., Obiero, R., Ruwal, D. and Honell, N. H., (2015). "Performance evaluation of hybrid thin layer solar tunnel-windmill dryer in the drying of brined and non-brined Tafi (Siganussutor) Fish". Agricultural Engineering International, CIGR Journal, 17(1): 273. http://www.cigrjournal.org, Accessed18 June,2015

Orengoh, P. and Kisumo, A., (2007). "Kenya: Countries Fish Sector Poised for Boom", Proc.: East African Business Week, Kampala, Uganda

Ozdemir, M. and Devres, Y. 0., (1999). "The thin layer drying characteristics of hazelnuts during roasting". Journal of Food Engineering, 42: 225- 233

Paulsen, M. R., Thomson, T. L. (1973). "Drying endysus of grain sorghum". TransASAE, 16: 537--40

Preston, T. R. and Rodriguez L., (2002). "Low-cost biodigester as the epicenter of ecological farming systems". Proceedings of the biodigester workshop, to prolong the shelf life of one of the commercially important food commodities in the tropics

Rahman, M. S., Perera, C. 0. and Theband C., (1998). "Desorption isotherm and heat pump drying kinetics of peas". Food Research International,30: 485-91

Sacilik, K., Keskin, R. and Elicin, A. K., (2006). "Mathematical modeling of solar tunnel drying of thin layer organic tomato". Journal of Food Engineering, 73:231-238

Saeed, I. E., Sopian, K. and Zainol Abidin Z., (2006). "Drying kinetics of Roselle (Hibiscus sabdariffa L.) dried in constant temperature and humidity chamber". Proceeding, of SPS Permata, Bangi, Malaysia, pp.143-148

Senadeera, W., Bhandari, B. R., Young, G. and Wijesinghe, B., (2003). "Influence of shapes of selected vegetable materials on drying kinetics during fluidized bed drying". Journal of Food Engineering, 58:277-283

Sogi, D.S., Shivhare, U.S., Garg, S. K. and Bawa, A. S., (2003). "Water sorption isotherms and drying characteristics of tomato seeds". Biosystems Engineering, 84:297-301

Thomson, T. L., Peart, P. M. and Foster, G. H., (1968). "Mathematical simulation of com drying: Anew model". Trans ASAE, 11:582- 6

Togrul, I. T. and Pehlivan, D., (2003). "Modeling of drying kinetics of single apricot". Journal of Food Engineering, 58:23-32

Togrul, I. T. and Pehlivan, D., (2002). "Mathematical modeling of solar drying of apricots in thin layer dryers". Journal ofFoodEngineering, 55: 209-216

Togrul, I. T. and Pehlivan D., (2004). "Modeling of thin layer drying kinetics of some fruits under open air sun drying process". Journal of Food Engineering, 65 (3): 413-425

Udo, I. U. and Umanah, S. I. (2017). Current Status of the Nigerian Aqua Feeds Industry: A Review. International Journal of Innovative Studies in Aquatic Biology and Fisheries (IJISABF) 3 (1):14-22

Upadhyay, A. H. K., Sharma and Sarkar, B. C., (2008). "Characterization and Dehydration Kinetics of Carrot Pomace". Agricultural Engineering International: The CIGRE journal Manuscript

Wang, C. Y. and Singh, R. P., (1978). "A single layer drying equation for rough rice".ASAE, (3001)

Wang, Z., Sun, J., Liao, X., Chen, F., Zhao, G., Wu, J. and Hu, X., (2007). "Mathematical modeling on hot air drying of thin layer apple pomace". Food Research International journal, 40: 39-46

Yagcioglu, A., Degirmencioglu, A., and Cagatay, F., (1999). Drying characteristic of laurel leaves under different conditions. In: A. Bascetincelik (Ed.), Proceedings of the 7th international congress on agricultural mechanization and energy, Adana, Turkey: Faculty of Agriculture,ukurova University pp. 565-569

Yaldiz, 0., Ertekin, C. and Uzan, H. E., (2001). "Mathematical modeling of thin layer solar drying of sultana grapes". Energy, 26(5): 457-465

Downloads

Published

2021-11-29